October 6, 2026 — A consumer has reported multiple Charge Worx Dual USB Power Bank 5000mAh units bursting out of their plastic casings, involving both used and unused power banks. This incident raises significant safety concerns, though the manufacturer, FOTO ELECTRIC SUPPLY CO., INC., states there is no recall of this product at this time.
Product Details
Product: Charge Worx Dual USB Power Bank 5000mAh
Incident Overview
On September 17, 2026, a consumer filed an incident report detailing alarming failures of multiple Charge Worx Dual USB Power Bank 5000mAh units. According to the report, the consumer had purchased a quantity of these power banks. Out of the units acquired, four that had been used to illuminate small LED Christmas lights, along with five completely unused units, inexplicably burst out of their plastic casings.
The consumer, demonstrating careful safety measures, reported that no fire or chemical burn had occurred due to immediate isolation of all affected units. All nine compromised power banks, as well as the single remaining unused unit, have been secured in a waterproof steel box outside, away from any buildings. The consumer expressed significant concern for safety and inquired about a potential recall, fearing that continued use could lead to injury.
Safety Concerns
The reported incident of multiple Charge Worx Dual USB Power Bank 5000mAh units bursting out of their plastic casings presents severe safety concerns for consumers:
- Immediate Dangers: The bursting of a power bank casing typically indicates a catastrophic internal battery failure, often involving rapid expansion, overheating, or a runaway thermal event. While no fire or chemical burns were reported in this specific incident thanks to the consumer’s prompt action, such events commonly precede or accompany battery fires, explosions, and the release of corrosive or toxic battery chemicals (electrolytes). These substances can cause severe skin burns, respiratory irritation, and eye injuries upon contact.
- Long-Term Risks: Even if a unit doesn’t immediately ignite, a compromised battery can remain unstable and pose a latent fire or chemical hazard. Improper disposal of these defective units could also lead to environmental contamination.
- Who Might Be Affected: Any consumer who owns or uses the Charge Worx Dual USB Power Bank 5000mAh could be at risk. This includes individuals using the power banks for various electronic devices, potentially unaware of the internal degradation. Children, who might be attracted to electronic gadgets, are particularly vulnerable if a unit bursts and exposes them to hot components or chemicals.
- Property Damage Potential: A bursting or exploding power bank can easily ignite nearby flammable materials, leading to house fires, damage to furniture, electronics, and other personal property. Chemical leaks can also stain and damage surfaces.
What Consumers Should Do
If you own a Charge Worx Dual USB Power Bank 5000mAh, please take the following urgent steps:
- Immediately Stop Use: Discontinue using the power bank immediately, regardless of whether it has shown signs of defect.
- Do Not Handle Compromised Units: If your unit has burst or shows signs of swelling, extreme heat, or leakage, do not attempt to charge, use, or dispose of it in regular household waste. Do not puncture, crush, or open the unit.
- Isolate Safely: Carefully place the power bank in a non-flammable container, such as a metal pot or bucket, and move it to a safe, isolated outdoor location away from combustible materials, children, and pets.
- Check Your Product: Verify that your power bank is the “Charge Worx Dual USB Power Bank 5000mAh” model. The brand and model information is typically printed on the unit itself.
- Disposal: Contact your local waste management facility or recycling center for specific instructions on how to safely dispose of lithium-ion batteries and hazardous waste in your area. Do not put these units in the trash or traditional recycling bins.
- Report the Incident: If you have experienced a similar incident or have concerns about your Charge Worx power bank, please file a report with the U.S. Consumer Product Safety Commission (CPSC) at www.cpsc.gov. This helps safety authorities track incidents and identify potential broader hazards.
Manufacturer’s Response
In response to the consumer’s inquiry about a recall, the manufacturer, FOTO ELECTRIC SUPPLY CO., INC., has stated that there is no recall of the Charge Worx Dual USB Power Bank 5000mAh at this time. Consumers are encouraged to follow the safety advice outlined above and report any further incidents to the CPSC.
Legal Help Available
If you or a loved one has been injured by a defective product or suffered property damage due to a product malfunction, you may be entitled to compensation. The experienced product liability attorneys at Farzan Law understand the complexities of defective product cases and can help you navigate the legal process. Farzan Law is a California based Personal Injury law firm focusing on protecting the rights of those wrongfully injured.
Licensed to practice law ONLY in California.
Contact us today for a free consultation: 424-325-3112
Our legal team has successfully represented clients in product liability cases involving defective appliances, automotive defects, medical devices, and consumer products. We work on a contingency fee basis, which means you don’t pay unless we win your case.
Note: This information is based on incident reports provided by the U.S. Consumer Product Safety Commission. If you find information that is incorrect, please contact us immediately so we can correct the post to reflect accurate information.
Disclaimer: The information provided in this post is not intended to be legal or medical advice. This article is based on publicly available incident reports. The incidents mentioned have not necessarily been independently verified or adjudicated.